lincoin w/ 3.5L
- Thread starter 1212
- Start date
- Status
sometimes its normal for cars to do this. I wouldn't sweat it. Others may disagree, and maybe they can tell you more. Those lincolns are nice cars.
maybe?
TSB
09-11-13 3.5L - ROUGH / ROLLING IDLE / IDLE SPEED DROPS BELOW SPECIFICATION
Publication Date: May 28, 2009
FORD: 2010 Fusion
LINCOLN: 2007-2010 MKZ
ISSUE:
Some 2007-2010 MKZ and 2010 Fusion Sport vehicles equipped with a 3.5L engine may exhibit a rough, rolling idle, or idle speed dropping below specification. This condition typically occurs most often in hot ambient temperatures with the A/C on when idling for extended periods.
ACTION:
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
Reprogram the powertrain control module (PCM) to the latest calibration using IDS release 61.04 and higher. This new calibration is not included in the VCM 2009.5 DVD. Calibration files may also be obtained at www.motorcraft.com.
Perform transmission control module (TCM) initial learning procedure. Refer to Workshop Manual Section 307-01A.
NOTE: VEHICLES EQUIPPED WITH A PCM AND TCM, REQUIRE A COORDINATED REPROGRAMMING. THIS COORDINATED REPROGRAMMING PROCEDURE MUST BE FOLLOWED EXACTLY AS OUTLINED BY THE IDS/PDS SCAN TOOL(S). FAILURE TO FOLLOW THE KEY CYCLE PROCEDURE WITHOUT WAITING FOR THE IDS PROMPTS, WILL CAUSE THE COORDINATED REPROGRAMMING TO FAIL. THE PCM WILL BE UPDATED BUT THE TCM WILL NOT BE UPDATED AND THE NEW FILES WILL NOT BE INSTALLED. IT IS CRITICAL TO FOLLOW THE IDS/PDS PROMPTS.
NOTE: AUTHORIZATION DECAL NOT REQUIRED.
WARRANTY STATUS:
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
091113A 2007-2010 MKZ, 2010 Fusion 3.5L: Reprogram The PCM And TCM Includes Time To Perform The TCM Initial Learning Procedure (Do Not Use With 12650D) 0.8 Hr.
DEALER CODING
BASIC PART NO. CONDITION CODE
RECAL 04
--------------------------------------------------------------------------------
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by "do-it-yourselfers". Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company's on-line technical resources.
Copyright © 2009 Ford Motor Company
TSB
09-11-13 3.5L - ROUGH / ROLLING IDLE / IDLE SPEED DROPS BELOW SPECIFICATION
Publication Date: May 28, 2009
FORD: 2010 Fusion
LINCOLN: 2007-2010 MKZ
ISSUE:
Some 2007-2010 MKZ and 2010 Fusion Sport vehicles equipped with a 3.5L engine may exhibit a rough, rolling idle, or idle speed dropping below specification. This condition typically occurs most often in hot ambient temperatures with the A/C on when idling for extended periods.
ACTION:
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
Reprogram the powertrain control module (PCM) to the latest calibration using IDS release 61.04 and higher. This new calibration is not included in the VCM 2009.5 DVD. Calibration files may also be obtained at www.motorcraft.com.
Perform transmission control module (TCM) initial learning procedure. Refer to Workshop Manual Section 307-01A.
NOTE: VEHICLES EQUIPPED WITH A PCM AND TCM, REQUIRE A COORDINATED REPROGRAMMING. THIS COORDINATED REPROGRAMMING PROCEDURE MUST BE FOLLOWED EXACTLY AS OUTLINED BY THE IDS/PDS SCAN TOOL(S). FAILURE TO FOLLOW THE KEY CYCLE PROCEDURE WITHOUT WAITING FOR THE IDS PROMPTS, WILL CAUSE THE COORDINATED REPROGRAMMING TO FAIL. THE PCM WILL BE UPDATED BUT THE TCM WILL NOT BE UPDATED AND THE NEW FILES WILL NOT BE INSTALLED. IT IS CRITICAL TO FOLLOW THE IDS/PDS PROMPTS.
NOTE: AUTHORIZATION DECAL NOT REQUIRED.
WARRANTY STATUS:
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
091113A 2007-2010 MKZ, 2010 Fusion 3.5L: Reprogram The PCM And TCM Includes Time To Perform The TCM Initial Learning Procedure (Do Not Use With 12650D) 0.8 Hr.
DEALER CODING
BASIC PART NO. CONDITION CODE
RECAL 04
--------------------------------------------------------------------------------
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by "do-it-yourselfers". Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company's on-line technical resources.
Copyright © 2009 Ford Motor Company
or maybe this?
TSB
09-13-10 3.5L/3.7L VCT CODES P0011, P0012, P0021, P0022 - RUNS ROUGH OR MISSES - BUILT ON OR BEFORE 12/15/2008
Publication Date: June 29, 2009
FORD: 2008-2009 Taurus X, Taurus
2007-2009 Edge
2009 Flex
LINCOLN: 2007-2009 MKZ
2009 MKS
2007-2009 MKX
MERCURY: 2008-2009 Sable
This article supersedes TSB 9-12-8 to update the Service Procedure and Part List.
ISSUE:
Some 2007-2009 Edge, MKX, MKZ, 2008-2009 Taurus, Taurus X, Sable, and 2009 Flex and MKS vehicles equipped with a 3.5L or 3.7L engine, may exhibit a malfunction indicator lamp (MIL) on and one or more diagnostic trouble codes (DTCs) P0011, P0012, P0021, P0022. Vehicle may also exhibit rough idle or misses.
ACTION:
Follow the service procedure steps to correct this condition.
SERVICE PROCEDURE
Using IDS, verify DTCs.
Verify vehicle build date on or before 12/15/2008.
If the vehicle was built after 12/15/2008 do not continue this procedure, refer to the Powertrain Controls/Emissions Diagnosis (PC/ED) for further diagnosis.
If the vehicle was built on or before 12/15/2008 proceed to Step 3.
Follow Workshop Manual (WSM), Section 303-00, to verify correct oil pressure.
If oil pressure is out of specification do not continue with this procedure and follow WSM, Section 303-00 diagnostics.
If oil pressure is in specification proceed to Step 4.
Use IDS scan tool to monitor parameter identifications (pids) VCTADV and VCTADV2. Replacement of the variable camshaft timing (VCT) housing is not necessary for either issue.
If VCTADV/VCTADV2 pids remain constant at 0 degrees while driving; or at 40 degrees at idle and while driving; then follow WSM, Section 303-01, to replace only the affected VCT solenoid.
If the VCT solenoid of the affected bank was not replaced in Step 4A; then follow WSM, Section 303-01, to replace only the affected VCT phaser.
PART NUMBER PART NAME
7T4Z-6A257-B Kit C/SHT - Left Hand Side
8T4Z-6A257-B Kit C/SHT - Right Hand Side
7T4Z-6M280-B Solenoid - VCT
WARRANTY STATUS:
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
091310A 2007-2009 MKZ: Replace The Right VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.2 Hrs.
091310A 2007-2009 Edge, MKX: Replace The Right VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.9 Hrs.
091310A 2008-2009 Taurus, Sable, Taurus X, 2009 MKS, Flex: Replace The Right VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.0 Hrs.
091310B 2007-2009 MKZ: Replace The Left VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 1.5 Hrs.
091310B 2008-2009 Taurus, Sable, Taurus X, 2009 MKS, Flex: Replace The Left VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 1.4 Hrs.
091310B 2007-2009 Edge, MKX: Replace The Left VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.2 Hrs.
091310C 2007-2009 Edge, MKX: Replace Two (2) VCT Solenoids, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 3.6 Hrs.
091310C 2008-2009 Taurus, Sable, Taurus X, 2009 MKS, Flex: Replace Two (2) VCT Solenoids, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.8 Hrs.
091310C 2007-2009 MKZ: Replace Two (2) VCT Solenoids, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.9 Hrs.
091310D 2007-2009 Edge, MKX: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 8.9 Hrs.
091310D 2009 Flex: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 7.8 Hrs.
091310D 2008-2009 Taurus, Sable, Taurus X, 2009 MKS: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 7.8 Hrs.
091310D 2007-2009 MKZ FWD: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 9.9 Hrs.
091310D 2007-2009 MKZ AWD: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 10.1 Hrs.
091310E 2007-2009 MKZ AWD: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 10.3 Hrs.
091310E 2009 Flex: Replace Two (2) Camshaft Sprockets, Includes Time To Check DTC’s; Verify Correct Oil Pressure (Do Not Use With Any Other Labor Operations) 7.9 Hrs.
091310E 2007-2009 Edge, MKX: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 9.0 Hrs.
091310E 2007-2009 MKZ FWD: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 10.0 Hrs.
091310E 2008-2009 Taurus, Sable, Taurus X, 2009 MKS: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 8.0 Hrs.
DEALER CODING
BASIC PART NO. CONDITION CODE
6A257 42
--------------------------------------------------------------------------------
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by "do-it-yourselfers". Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company's on-line technical resources.
Copyright © 2009 Ford Motor Company
TSB
09-13-10 3.5L/3.7L VCT CODES P0011, P0012, P0021, P0022 - RUNS ROUGH OR MISSES - BUILT ON OR BEFORE 12/15/2008
Publication Date: June 29, 2009
FORD: 2008-2009 Taurus X, Taurus
2007-2009 Edge
2009 Flex
LINCOLN: 2007-2009 MKZ
2009 MKS
2007-2009 MKX
MERCURY: 2008-2009 Sable
This article supersedes TSB 9-12-8 to update the Service Procedure and Part List.
ISSUE:
Some 2007-2009 Edge, MKX, MKZ, 2008-2009 Taurus, Taurus X, Sable, and 2009 Flex and MKS vehicles equipped with a 3.5L or 3.7L engine, may exhibit a malfunction indicator lamp (MIL) on and one or more diagnostic trouble codes (DTCs) P0011, P0012, P0021, P0022. Vehicle may also exhibit rough idle or misses.
ACTION:
Follow the service procedure steps to correct this condition.
SERVICE PROCEDURE
Using IDS, verify DTCs.
Verify vehicle build date on or before 12/15/2008.
If the vehicle was built after 12/15/2008 do not continue this procedure, refer to the Powertrain Controls/Emissions Diagnosis (PC/ED) for further diagnosis.
If the vehicle was built on or before 12/15/2008 proceed to Step 3.
Follow Workshop Manual (WSM), Section 303-00, to verify correct oil pressure.
If oil pressure is out of specification do not continue with this procedure and follow WSM, Section 303-00 diagnostics.
If oil pressure is in specification proceed to Step 4.
Use IDS scan tool to monitor parameter identifications (pids) VCTADV and VCTADV2. Replacement of the variable camshaft timing (VCT) housing is not necessary for either issue.
If VCTADV/VCTADV2 pids remain constant at 0 degrees while driving; or at 40 degrees at idle and while driving; then follow WSM, Section 303-01, to replace only the affected VCT solenoid.
If the VCT solenoid of the affected bank was not replaced in Step 4A; then follow WSM, Section 303-01, to replace only the affected VCT phaser.
PART NUMBER PART NAME
7T4Z-6A257-B Kit C/SHT - Left Hand Side
8T4Z-6A257-B Kit C/SHT - Right Hand Side
7T4Z-6M280-B Solenoid - VCT
WARRANTY STATUS:
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
091310A 2007-2009 MKZ: Replace The Right VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.2 Hrs.
091310A 2007-2009 Edge, MKX: Replace The Right VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.9 Hrs.
091310A 2008-2009 Taurus, Sable, Taurus X, 2009 MKS, Flex: Replace The Right VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.0 Hrs.
091310B 2007-2009 MKZ: Replace The Left VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 1.5 Hrs.
091310B 2008-2009 Taurus, Sable, Taurus X, 2009 MKS, Flex: Replace The Left VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 1.4 Hrs.
091310B 2007-2009 Edge, MKX: Replace The Left VCT Solenoid, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.2 Hrs.
091310C 2007-2009 Edge, MKX: Replace Two (2) VCT Solenoids, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 3.6 Hrs.
091310C 2008-2009 Taurus, Sable, Taurus X, 2009 MKS, Flex: Replace Two (2) VCT Solenoids, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.8 Hrs.
091310C 2007-2009 MKZ: Replace Two (2) VCT Solenoids, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 2.9 Hrs.
091310D 2007-2009 Edge, MKX: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 8.9 Hrs.
091310D 2009 Flex: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 7.8 Hrs.
091310D 2008-2009 Taurus, Sable, Taurus X, 2009 MKS: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 7.8 Hrs.
091310D 2007-2009 MKZ FWD: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 9.9 Hrs.
091310D 2007-2009 MKZ AWD: Replace One (1) Camshaft Sprocket, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 10.1 Hrs.
091310E 2007-2009 MKZ AWD: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 10.3 Hrs.
091310E 2009 Flex: Replace Two (2) Camshaft Sprockets, Includes Time To Check DTC’s; Verify Correct Oil Pressure (Do Not Use With Any Other Labor Operations) 7.9 Hrs.
091310E 2007-2009 Edge, MKX: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 9.0 Hrs.
091310E 2007-2009 MKZ FWD: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 10.0 Hrs.
091310E 2008-2009 Taurus, Sable, Taurus X, 2009 MKS: Replace Two (2) Camshaft Sprockets, Includes Time To Diagnose (Do Not Use With Any Other Labor Operations) 8.0 Hrs.
DEALER CODING
BASIC PART NO. CONDITION CODE
6A257 42
--------------------------------------------------------------------------------
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by "do-it-yourselfers". Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company's on-line technical resources.
Copyright © 2009 Ford Motor Company
now that was a mouth full of info,,,,amen
- Status
Similar threads
