Recent Topics
Rough service tough light bulb 1ยข at Home Depot
by JLawrence08648 - 11/17/19 08:40 PM
2015 F150 5.0 8592 miles
by Buzzinhalfdozen - 11/17/19 08:36 PM
MOPAR MO-285 FACTORY OIL FILTER CUT OPEN
by 53' Stude - 11/17/19 07:43 PM
Best Garage Door Seals
by Gebo - 11/17/19 07:18 PM
Bar oil as fogging oil
by WA1DH - 11/17/19 06:47 PM
Fram PH2 ExtraGuard Cut Open
by A310 - 11/17/19 06:38 PM
C&P Pentius UFXL PH16-equiv.
by 92saturnsl2 - 11/17/19 06:18 PM
Fleetguard WF2074 Coolant Filter Cut Open
by Pyrotechnic - 11/17/19 05:24 PM
Cuts on tire sidewall
by mclasser - 11/17/19 03:19 PM
Hyundai Theta II Engine in Newer Years
by smc733 - 11/17/19 02:41 PM
Walmart deals
by Deere John - 11/17/19 02:33 PM
Grumpy Kid
by wings&wheels - 11/17/19 01:57 PM
h9/95R FLA Batteries
by TXCarGeek - 11/17/19 01:40 PM
Preventative parking brake service
by Donald - 11/17/19 01:26 PM
Should I run an AC Delco Ultraguard gold?
by JHZR2 - 11/17/19 01:13 PM
Ford Ecoboost 400 at Homestead Miami Speedway
by bdcardinal - 11/17/19 01:08 PM
Strut mount, Moog vs KYB?
by jbutch - 11/17/19 01:07 PM
Is bar and chain oil hard on rubber?
by jqgz - 11/17/19 12:53 PM
TSC - Mobil Delvac $10.99
by Greg L - 11/17/19 12:42 PM
Newest Members
Joey737, bdavis218, XTR74, 2009Caraman, redmonkey01
69898 Registered Users
Who's Online Now
134 registered members (4WD, A310, 2010Civic, 2015_PSD, 77GrandPrix, 69Torino, 14 invisible), 2,215 guests, and 22 spiders.
Key: Admin, Global Mod, Mod
Forum Statistics
Forums67
Topics297,563
Posts5,118,076
Members69,898
Most Online3,589
Nov 2nd, 2019
Donate to BITOG
Print Thread
Hop To
Son's van is giving multiple warning lights that come and go - vehicle dies #5142929 06/24/19 02:28 PM
Joined: Sep 2015
Posts: 4,329
69GTX Offline OP
OP Offline
Joined: Sep 2015
Posts: 4,329
Trying to give some ideas to my son. First the ABS warning light came on. Then the check engine and engine oil warning lights. Then they went away and everything was fine for a few
miles. Then they came back again in similar sequence. These lights are flashing, not steady. He stopped the vehicle...then it wouldn't start or even engage the starter. Just had the head lights available. A short while later he tried again and it started....warning lights were gone. This sequence repeated again. Warning Lights Flashing. Car won't start again. Didn't say if he turned it off or the car stalled out.

Sounds like an intermittent ground on the electrical system. Maybe corrosion in the battery lines/grounding. He did say one of the door panels was just removed for some work. Maybe that left an exposed wire or a strained wire that's grounding the electrical system at times....dropping the voltage and/or current.

comments? It's a 2002 Dodge Caravan.

Last edited by 69GTX; 06/24/19 02:31 PM.

----------------

2001 Lincoln Cont 4.6L DOHC/ 50K mi / QS HM 5w30 / FUG XG2
1999 Camaro SS M6 /19K /Mobil 1 0w40 /Fram UG /GM MTL-ATF
1969 Ply GTX/RRs
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5142933 06/24/19 02:32 PM
Joined: Sep 2015
Posts: 2,246
M
mk378 Offline
Offline
M
Joined: Sep 2015
Posts: 2,246
If the starter doesn't turn (it may click, but it doesn't make that "car trying to start" sound) when you turn the key, check for bad connections at the battery.

Last edited by mk378; 06/24/19 02:32 PM.
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5142954 06/24/19 02:58 PM
Joined: Sep 2015
Posts: 4,329
69GTX Offline OP
OP Offline
Joined: Sep 2015
Posts: 4,329
I told him to check anything going to and from battery to alternator and/or grounding...especially corrosion or bare wires. He said every connection was sealed or taped. He wandered into one of the auto retail places and they all jumped on alternator failing. Which makes sense since they'd like to sell him a new alternator. Currently the car is driving around fine. I told him not to turn it off until he gets where he's going. It could also be a heat related issue stressing a weakened or aged electrical system as it's 100 deg F today where he's at.

The two times he turned the car off - it wouldn't restart right away. He had to wait a bit. Heat? And in each case he heard nothing from the starter engaging the flywheel and cranking the engine.

Last edited by 69GTX; 06/24/19 03:00 PM.

----------------

2001 Lincoln Cont 4.6L DOHC/ 50K mi / QS HM 5w30 / FUG XG2
1999 Camaro SS M6 /19K /Mobil 1 0w40 /Fram UG /GM MTL-ATF
1969 Ply GTX/RRs
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5142959 06/24/19 03:06 PM
Joined: Oct 2015
Posts: 250
D
DerbyDave Offline
Offline
D
Joined: Oct 2015
Posts: 250
Check and double check all the grounds. I had a loose negative cable on my battery a while back, the dash lights would randomly light up then the car would die. Battery and alternator tested fine. I tightened the negative cable and it has never done it again. Your situation sounds suspiciously similar.


2005 Buick Terraza
2007 Honda Ridgeline
1986 Suzuki Cavalcade
1986 Suzuki Intruder
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5142961 06/24/19 03:08 PM
Joined: Aug 2013
Posts: 613
T
tcp71 Offline
Offline
T
Joined: Aug 2013
Posts: 613
Battery issues can cause all kinds of crazy sensor issues. My bet is a plate in the battery is separating when hot. As it cools, connections are re-established and the van starts.If you can change the battery with another and try it, it might save the cost of buying a new one to confirm.


2016 F150 Eco: Edge 0w40
2005 Sienna 3.3: NAPA 5w30 syn. (varies)
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5142969 06/24/19 03:22 PM
Joined: Sep 2015
Posts: 4,329
69GTX Offline OP
OP Offline
Joined: Sep 2015
Posts: 4,329
Actually, he told me they had just put a new battery in the van. But checking all the connections makes sense. He did verify all the top connections were clean and tight.


----------------

2001 Lincoln Cont 4.6L DOHC/ 50K mi / QS HM 5w30 / FUG XG2
1999 Camaro SS M6 /19K /Mobil 1 0w40 /Fram UG /GM MTL-ATF
1969 Ply GTX/RRs
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5142977 06/24/19 03:33 PM
Joined: Sep 2015
Posts: 2,246
M
mk378 Offline
Offline
M
Joined: Sep 2015
Posts: 2,246
New parts aren't necessarily good.

When it won't start you need to use a voltmeter to see where the voltage is being lost.

Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5142978 06/24/19 03:34 PM
Joined: Feb 2006
Posts: 2,817
C
Chris Meutsch Offline
Offline
C
Joined: Feb 2006
Posts: 2,817
Check chassis grounds on the negative side. My car was flashing dash lights, alt and battery checked out fine. Found a broken cable, fixed it, all is well.


2005 Honda CR-V EX, 278k
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5143186 06/24/19 08:00 PM
Joined: Dec 2016
Posts: 2,548
M
maverickfhs Offline
Offline
M
Joined: Dec 2016
Posts: 2,548
Ground and probably alternator test. Good luck.


2006 Civic EX 205K/AT
2006 Acura TSX 187K/AT
2007 Accord VP 151K/AT
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5143219 06/24/19 08:43 PM
Joined: Feb 2017
Posts: 38
B
BozoDeClowne Offline
Offline
B
Joined: Feb 2017
Posts: 38
Had a similar problem with an 04 with the 3.8L. Positive battery cable looked fine at the connector, but was terribly corroded at the crimp. So much so that about half of the strands had snapped. Same sort of thing - random lights and then stopping dead while driving. Every couple of years I'd have to cut a bit off the ends and install one of those "repair" cable jumpers as the cable would be too short to reach the top of the battery.


[Linked Image]


Down like a clown, Charlie Brown...
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: mk378] #5143223 06/24/19 08:48 PM
Joined: Mar 2015
Posts: 7,044
B
bbhero Online Content
Online Content
B
Joined: Mar 2015
Posts: 7,044
Originally Posted by mk378
New parts aren't necessarily good.

When it won't start you need to use a voltmeter to see where the voltage is being lost.



Great point ^^^^^^^^

I had a hoopty Doo brand new alternator fail within literally 10 miles... Car died on the way to my lady's family house.


Nissan Altima 3.5 Coupe
Cam2 Dexos1 Gen 2 5w30 Wix 57356 Oil filter
"Treat your family like your friends and treat your friends like your family."
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5143267 06/24/19 09:51 PM
Joined: Sep 2015
Posts: 4,329
69GTX Offline OP
OP Offline
Joined: Sep 2015
Posts: 4,329
Good inputs. Thanks all. Will have him closely check all those ground and battery points.


----------------

2001 Lincoln Cont 4.6L DOHC/ 50K mi / QS HM 5w30 / FUG XG2
1999 Camaro SS M6 /19K /Mobil 1 0w40 /Fram UG /GM MTL-ATF
1969 Ply GTX/RRs
Re: Son's work van is giving multiple warning lights that come and go - vehicle dies [Re: 69GTX] #5143451 06/25/19 06:25 AM
Joined: Jun 2011
Posts: 1,720
W
wag123 Offline
Offline
W
Joined: Jun 2011
Posts: 1,720
Originally Posted by tcp71
Battery issues can cause all kinds of crazy sensor issues. My bet is a plate in the battery is separating when hot. As it cools, connections are re-established and the van starts.If you can change the battery with another and try it, it might save the cost of buying a new one to confirm.

Originally Posted by 69GTX
Actually, he told me they had just put a new battery in the van. But checking all the connections makes sense. He did verify all the top connections were clean and tight.
Just because the battery is "new" doesn't mean that it isn't defective. I have seen this sort of thing before. Don't dismiss this possibility.

Previous Thread
Index
Next Thread

BOB IS THE OIL GUY® Powered by UBB.threads™